基于小焦炉试验的焦炭硫含量预测

燃料与化工 ›› 2021, Vol. 52 ›› Issue (1): 9-12.

基于小焦炉试验的焦炭硫含量预测

张明星杜屏雷鸣

江苏省（沙钢）钢铁研究院，张家港215625

出版日期:2021-01-23 发布日期:2021-01-11

Prediction on sulfur content in coke from pilot oven

Zhang Mingxing Du Ping Lei Ming

Iron and Steel Research Institute of Shasteel,Jiangsu Province,Zhangjiagang 215625,China

Online:2021-01-23 Published:2021-01-11

摘要/Abstract

摘要： 以40 kg试验焦炉为工具，测定了单种煤及配合煤的硫含量、成焦率、硫残余率等指标，以此为基础建立了焦炭硫含量的预测方程。结果表明，通过积累单种煤数据预测配合煤所生产焦炭的硫含量是可行的，在焦炭硫含量不超过1%时，绝对误差平均在0.03%～0.05%。

关键词: 炼焦煤, 挥发分, 焦炭硫含量, 成焦率, 硫残余率

Abstract: The sulfur content,coke rate and sulfur residual ratio of single coal and blended coal were determined by conducting 40 kg coke oven experiment.Thus the prediction equation for coke sulfur content in blended coal was established.The result shows that it is feasible to predict the coke sulfur content in blended coal by accumulating single coal datum.When the coke sulfur content of blended coal is no higher than 1%,the average absolute error is about 0.03%～0.05%.

Key words:

"> Coking coal, Volatile matters, Sulfur content in coke, Coke rate, Sulfur residual ratio

中图分类号:

TQ520.62A

张明星杜屏雷鸣. 基于小焦炉试验的焦炭硫含量预测[J]. 燃料与化工, 2021, 52(1): 9-12.

Prediction on sulfur content in coke from pilot oven. Prediction on sulfur content in coke from pilot oven[J]. FUEL & CHEMICAL PROCESSES, 2021, 52(1): 9-12.

[1]	方锦浩洪叶发. 熄焦水中硫酸根离子对焦炭中硫含量的影响[J]. 燃料与化工, 2022, 53(3): 31-32.
[2]	洪泽李成才. 不同炼焦煤成焦光学组织特征及相关研究[J]. 燃料与化工, 2022, 53(3): 5-11.
[3]	李贺夏丽丽韩计委. 煤岩学方法在分析炼焦煤质量中的应用[J]. 燃料与化工, 2022, 53(1): 4-5.
[4]	陈明明张海平王和喜徐庆伟. 俄罗斯低硫肥煤配煤炼焦实践[J]. 燃料与化工, 2021, 52(3): 8-10.
[5]	任华伟, . 炼焦煤中不同粒级组分的煤质差异研究[J]. 燃料与化工, 2021, 52(2): 9-14.
[6]	杨野付铁林赵宇科范懿凡郭瑞. 炼焦煤热解过程交互行为与气孔特征的关系[J]. 燃料与化工, 2020, 51(4): 24-27.
[7]	侯有德牟晓龙江全勇白利洲陈杰忠. 焦炭主要指标相关性研究[J]. 燃料与化工, 2016, 47(5): 10-13.
[8]	王少波. 结焦率的计算方法[J]. 燃料与化工, 2016, 47(3): 19-20.
[9]	孙德财. 配煤结构对捣固焦炉推焦电流的影响[J]. 燃料与化工, 2015, 46(2): 32-33.
[10]	王洪顺周永平张国星高立东李娟. 高挥发分气煤变质研究及应用[J]. 燃料与化工, 2013, 44(1): 21-23.
[11]	王慧1 曹素梅2 史世庄1 史媛1 万洋1. 炼焦煤与焦炭间硫转化关系的研究[J]. 燃料与化工, 2011, 42(2): 7-10.